The following fruits were rated as excellent or good by the University of Georgia for their quality after drying: apples, apricots, bananas, cherries, citrus peel, coconuts, currants, dates, figs, grapes, nectarines, papayas, peaches, pears, pineapples, plums and rhubarb. Other fruits also are suitable for drying.
Preparing Fruits for Dehydration
Select high-quality, fully ripe fruit, and discard any fruit with decay, bruises or mold. Thoroughly wash and clean fruits to remove dirt. Cut foods into c-inch to -inch slices. The higher the water content, the larger the slice size should be. Small slices of high-moisture foods would disappear when all the moisture has evaporated.
Pretreating light-colored fruits before drying is important for the quality and safety of the final product. Soaking the sliced fruit in an acidic solution preserves the color and texture of the dried fruits, and it increases the destruction of potentially harmful bacteria during drying. These treatment methods are courtesy of Colorado State University Extension.
1. Ascorbic Acid Pretreatment: Pure crystals of ascorbic acid (vitamin C) can be found at supermarkets and drug stores. Stir 2 tablespoons of pure ascorbic acid crystals into 1 quart of cold water. This amount of solution treats about 10 quarts of cut fruit. For smaller batches, adjust proportions accordingly. Soak the fruit for 10 minutes, then remove it with a slotted spoon, drain it well and dehydrate it.
2. Citric Acid Pretreatment: Citric acid is available in the canning section of many supermarkets. Stir 1 teaspoon of citric acid into 1 quart of cold water. Add the fruit and allow it to soak for 10 minutes, then remove it with a slotted spoon, drain it well and dehydrate it.
3. Lemon Juice Pretreatment: Mix equal parts of lemon juice and cold water. Add the fruit and allow it to soak for 10 minutes, then remove it with a slotted spoon, drain it well and dehydrate it.
Some fruits have tough skins. For successful dehydration, the skins must be cracked before being dried as whole fruits. To crack the skins of grapes, plums, cherries, berries and other fruits with tough skins, dip the fruits in briskly boiling water for 30 to 60 seconds, then dip them in very cold water. Drain them on absorbent towels before placing them on drying trays.
Drying is not a precise method of food preservation, and the amount of drying time will vary depending on the equipment, moisture content of the fruit and the humidity in the air. Spray a cookie sheet or similar flat tray with vegetable spray, or line the tray with plastic wrap or parchment paper and spray with vegetable spray. Another option is to use the specially designed plastic sheets for electric dehydrators, and follow the manufacturers directions.
Oven drying: Test your oven to be sure it can maintain a low enough temperature; otherwise, case hardening may occur. This is the formation of a crust on the food, which prevents the interior from drying properly.
To test your oven, set it to the lowest setting. Place an oven-safe thermometer on the rack where food will be placed. Leave the oven door open 2 to 6 inches. Place a fan near the open door to circulate air. Check the temperature. If your oven can maintain a low enough temperature (140 to 145 F), it may be used for food dehydration. Racks should be 2 inches apart, with at least 3 inches of clearance from the top or bottom to the rack. See Table 1 for approximate drying times.
If you wanna know more information or drying fruits quickly, please learn more information about GuanFengFreeze Dried Fruit Machineor check below link:https://www.gf-machine.com/product/quick-freezing-equipment/